Lincoln - Walker Products, Inc. - Executive Summary
BOETTCHER ENTERPRISES, INC. |
Jarold W. Boettcher Telephone (785)738-4181
President Fax (785)738-4256
424 East Elliott
P.O. Box 486
Beloit, KS 67420
For further information contact: Craig Walker, Plant Manager
Risk Management Plan - EXECUTIVE SUMMARY
1. The Facility Policy
The owners, management, and employees of Walker Products are committed to
the prevention of any accidental releases of anhydrous ammonia. If an accidental release
should occur, the facility is prepared to work with the local fire company, or other
authorities, to mitigate any release and minimize the impact of the release to people and
2. Facility Information
- Walker Products, 414 S. Sixth, Lincoln, KS 67455, (785)524-4107
2 miles west of the Hwy.14 & 18 junction, and 1/4 mile south.
- The primary activity at the facility is the storage of fertilizers for sale to farmers.
- Anhydrous ammonia is received, stored, and distributed for direct application.
- The maximum quant
ity stored would be 53,000 pounds in our12,000 gallon
3. The worst-case release scenario and the alternative release scenario.
a. The worst-case release scenario would be the release of the total contents of a
storage tank released as a gas over 10 minutes. The maximum quantity released would be
53,000 pounds, which represents the volume of the largest storage tank at 85 percent
capacity as limited by design standards. The distance to the endpoint (point of dispersion
to 200 ppm) is 1.63 miles.
b. The alternative release scenario based on the five-year accident history (or the
most likely potential incident is a release from a pipe leak. The distance to the endpoint
(point of dispersion to 200 ppm) is 0.47 miles.
4. The accidental release prevention program.
The facility has implemented the provisions of "Safety Requirements for the
Storage and Handling of Anhydrous Ammonia, K-61.1", published by The American
National Standards Institute, Inc., and t
he standards of the U.S. Occupational Safety and
Health Administration (OSHA), 29 CFR 1910.111, "Storage and handling of anhydrous
5. The Five-year Accident History
There have been no accidental releases of anhydrous ammonia in the past five
- have caused any deaths, injuries, or significant property damage at the
- to our knowledge, have resulted in offsite deaths, injuries, evacuations,
sheltering in place, property damage, or environmental damage.
6. The emergency response program.
- The facility has:
a. a written emergency action plan, in accordance with OSHA standard, 29 CFR
b. provided state and local authorities the emergency planning and community
right-to-know information as required under SARA Title III (EPCRA).
c. a written emergency response program, in accordance with OSHA standard, 29
CFR 1910.120, including pre-emergency planning and employee train
7. Planned changes to improve safety.
Safety improvement is an on-going process at the facility. Periodic evaluations are
performed to assess the maintenance of safe conditions. There are no additional specific
anhydrous ammonia safety recommendations for implementation at this time.