Western Farm Service, Tangent - Executive Summary

| Accident History | Chemicals | Emergency Response | Registration | Source | Executive Summary |

Agrium / Western Farm Service 
Tangent Facility 
 
 
1.  Facility Accidental Release Policy 
 
The owners, management, and employees of Western Farm Service's Tangent facility (herein referred to as the Facility) at 32092 Old Highway 34 East, Tangent, Oregon, 97389 are committed to the prevention of any accidental release of anhydrous ammonia.  If an accidental release should occur, the facility is prepared to work with the local fire department, or other authorities to mitigate any release and minimize the impact of the release to people and the environment.  A detailed emergency response plan has been developed and will be implemented in the event of an accidental release. 
 
2.  Facility Information 
 
The primary activity at the Facility is the storage, blending, and sale of fertilizers, in addition to, the sale of pre-packaged agricultural chemicals to farmers.  
 
Anhydrous ammonia is received in railcar, stored, and distributed for both direct application and for blending into mixed grade f 
ertilizers for crop production nutrients.  
 
Anhydrous ammonia is received and stored in one 30,000-gallon railcar at the site.  The maximum quantity of anhydrous ammonia handled in this process is 153,000 pounds. 
 
3.  The Worst-Case Release Scenario and Alternative Release Scenario 
 
A.  Anhydrous Ammonia Worst-case and Alternative Release Scenarios   
The worst-case release scenario is failure of the largest storage tank when filled to the greatest amount releasing 153,000 pounds of anhydrous ammonia.  The distance to the endpoint (point of dispersion to 200 ppm) is 2.78 miles.   The alternative release scenario, based on the PHA scenarios (or the most likely potential incident) and  is a release of 26,638 pounds of anhydrous ammonia from a broken 3-inch diameter pipe.  The distance to the endpoint (point of dispersion to 200 ppm) is 1.56 miles. 
 
4.  Accidental Release Prevention Program 
 
Anhydrous Ammonia:  The Facility has implemented the provisions of the "Safety Requirements for Sto 
rage and Handling of Anhydrous Ammonia, K-61.1", published by the American National Standards Institute, Inc.; and the standards of the U.S. Occupational Safety and Health Administration (OSHA), 29 CFR 1910.111, "Storage and Handling of Anhydrous Ammonia." 
 
5.  Five-year Accident History 
 
a. There have been no accidental releases or near misses of anhydrous ammonia or aqua ammonia in the past five years that: 
 
1.  Have caused any deaths, injuries, or significant property damage at the facility; nor 
 
2.  Have resulted in off-site deaths, injuries, evacuations, sheltering in place, property  damage, or environmental damage. 
 
6.  The Emergency Response Program 
 
The facility's emergency response program was written in accordance with the following regulations: 
 
OSHA 29 CFR 1910.38; 
 
OSHA 29 CFR 1910.120; and 
 
7.  Planned Changes to Improve Safety 
 
Safety improvement is an on-going process at the facility.  Periodic evaluations are performed to assess the maintenance of safe conditions.  Sp 
ecific planned changes to the anhydrous ammonia, aqua ammonia, and propane processes at the facility are listed in the Facility PHAs. In summary, planned changes address the review and development of Standard Operating Procedures for regulated onsite processes.
Click to return to beginning