ADA BELTRAMI CO-OP ASSN.-FERTILE - Executive Summary |
|
ADA BELTRAMI CO-OP ASSN. 202 WEST MAIN ADA, MN 56510 FERTILE DIVISION For further information contact Mark Langved, Manager, 218-945-6067 Risk Management Plan- EXECUTIVE SUMMARY 1. The Facility Policy The owners, management, and employees of Ada Beltrami Co-op Assn. are committed to the prevention of any accidental releases of anhydrous ammonia. If an accidental release should occur, the facility is prepared to work with the local fire department or other authorities to mitigate any release and minimize the impact of the release to the public and the environment. 2. Facility Information The primary activitiy at the facility is the storage of anhydrous ammonia. Anhydrous ammonia is received, stored and distributed for direct application. Anhydrous ammonia is used for crop production nutrients. The maximum quantity of ammonia stored would be 130,000 pounds in our 30,000 gallon storage tank. The maximum quantity handled would be the unloading of a tank truck holding 40,000 pounds. 3. The worst-case release scenario and the alternative release scenario. Anhydrous Ammonia: The worst-case release scenario for anhydrous ammonia would be the release of the total contents of a 30,000 gallon storage tank when filled to 85 percent capacity (130,000 pounds) over a 10 minute time period. According to TFI Guidance Tables, the distance to endpoint (point of dispersion to 200 ppm) is 1.12 miles. The alternate release scenario for anhydrous ammonia based on the hazard review is a 2 minute release from a break in a 3 inch pipe. The distance to the endpoint (point of dispersion to 200 ppm) is .78 miles. 4. The Accidental Release Prevention Program Anhydrous Ammonia: The facility has implemented the provisions of "Safety Requirements for the Storage and Handling of Anhydrous Ammonia, K-61.1, published by the American National Standards Institute, Inc. and the Standards of the U.S. Occupational Safety and Health Administration (OSHA), 29 CFR 1910.111, "Storage and Handling of Anhydrous Ammonia". In addition, MN Dept. of Ag rules are followed. 5. The Five-Year Accident History There have been no accidental releases of propane or anhydrous ammonia in the past five years that have caused any deaths, injuries, or significant property damage at the facility, nor to our knowledge, have resulted in offsite deaths, injuries, evacuations, sheltering in place, property damage or environmental damage. 6. The Emergency Response Program The facility has: a. A written emergency action plan, in accordance with OSHA standard 29 CFR 1910.38; b. Provided state and local authorities the emergency planning and community right-to-know information as required under SARA Title III (EPCRA). c. Coordinated with local emergency responders. 7. Planned Changes to Improve Safety Safety improvement is an on-going process at the facility. Periodic evaluations are performed to assess the maintenance of safe conditions. There are no additional specific anh ydrous ammonia safety recommendations or propane safety recommendations for implementation at this time. |