CROPMATE COMPANY/UAP, FRANKLIN,MN - Executive Summary |
|
For further information contact: Dave Johnson, Plant Manager RISK MANAGEMENT PLAN - EXECUTIVE SUMMARY I. THE FACILITY POLICY: A. THE OWNER, MANAGEMENT, AND EMPLOYEES OF UAP / CROPMATE COMPANY, HWY. 19 FRANKLIN, MN. ARE COMMITTED TO THE PREVENTION OF ANY ACCIDENTAL RELEASE OF ANHYDROUS AMMONIA. IF AN ACCIDENTAL RELEASE SHOULD OCCUR, THE FACILITY IS PREPARED TO WORK WITH THE LOCAL FIRE DEPARTMENT, OR OTHER AUTHORITIES, TO MITIGATE ANY RELEASE AND TO MINIMIZE THE IMPACT OF THE RELEASE ON PEOPLE AND THE ENVIRONMENT. II. FACILITY INFORMATION: A. THE PRIMARY ACTIVITY AT THE FACILITY IS THE STORAGE AND HANDLING OF ANHYDROUS AMMONIA FOR PRODUCTION OF NON-HAZARDOUS LIQUID FERTILIZER FOR AGRICULTURAL USE. B. ANHYDROUS AMMONIA IS RECEIVED, STORED, AND BLENDED AS A FERTILIZER NUTRIENTS FOR AGRICULTURAL CROPS. C. THE MAXIMUM QUANTITY THAT CAN BE STORED IS 52530 LBS., IN ONE 12,000 GAL. STORAGE TANK. THE NORMAL METHOD OF RECEIVI NG AMMONIA AT THE FACILITY IS BY TRUCK TRANSPORT CONTAINING 43,000 POUNDS. (Note: maximum quantity allowed to be stored is 85% of storage tank size) III. THE WORST-CASE RELEASE SCENARIO AND THE ALTERNATIVE RELEASE SCENARIO: A. THE WORST-CASE RELEASE SCENARIO WOULD BE THE RELEASE OF THE TOTAL CONTENTS OF A STORAGE TANK AS A GAS OVER 10 MINUTES. THE MAXIMUM QUANTITY RELEASED WOULD BE 52530 POUNDS, WHICH REPRESENTS THE VOLUME OF THE STORAGE TANK AT 85 PERCENT CAPACITY AS LIMITED BY DESIGN STANDARDS. THE DISTANCE TO THE ENDPOINT (point of dispersion to 200 ppm) IS 0.84 MILES. B. THE ALTERNATIVE RELEASE SCENARIO, BASED ON THE FIVE-YEAR ACCIDENT HISTORY (OR THE MOST LIKELY POTENTIAL INCIDENT) IS A RELEASE FROM A BREAK IN A TRANSFER HOSE. THE DISTANCE TO THE ENDPOINT (point of dispersion to 200 ppm) IS 0.56 MILES. IV. THE ACCIDENT RELEASE PREVENTION PROGRAM: 1. THE FACILITY HAS IMPLEMENTED THE PRO VISIONS OF "SAFETY REQUIREMENTS FOR THE STORAGE AND HANDLING OF ANHYDROUS AMMONIA, K-61.1", PUBLISHED BY THE AMERICAN NATIONAL STANDARDS INSTITUTE, INC. . THE STANDARDS OF THE U.S. OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA), 29 CFR 1910.111, "STORAGE AND HANDLING OF ANHYDROUS AMMONIA". V. THE FIVE-YEAR ACCIDENT HISTORY: A. THERE HAS BEEN NO ACCIDENTAL RELEASES OF ANHYDROUS AMMONIA IN THE PAST FIVE YEARS THAT: 1. HAVE CAUSED ANY DEATH, INJURIES, OR SIGNIFICANT PROPERTY DAMAGE AT THE FACILITY, NOR 2. TO OUR KNOWLEDGE, HAVE RESULTED IN OFF-SITE DEATHS, INJURIES, EVACUATIONS, SHELTERING IN PLACE, PROPERTY DAMAGE, OR ENVIRONMENTAL DAMAGE. VI. THE EMERGENCY RESPONSE PROGRAM: 1. THE FACILITY HAS: A. A WRITTEN EMERGENCY ACTION PLAN, IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1 910.38. B. PROVIDED TO THE STATE AND LOCAL AUTHORITIES, THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW INFORMATION AS REQUIRED UNDER SARA TITLE III (EPCRA). C. A WRITTEN EMERGENCY RESPONSE PROGRAM, IN ACCORDANCE WITH OSHA STANDARD, 29 CFR 1910.120, INCLUDING PRE-EMERGENCY PLANNING AND EMPLOYEE TRAINING. VII. PLANNED CHANGES TO IMPROVE SAFETY: SAFETY IMPROVEMENTS ARE AN ON-GOING PROCESS AT THE FACILITY. PERIODIC EVALUATIONS ARE PERFORMED TO ASSESS THE MAINTENANCE OF SAFE CONDITIONS. A. THERE ARE NO ADDITIONAL SPECIFIC ANHYDROUS AMMONIA SAFETY RECOMMENDATIONS FOR IMPLEMENTATION AT THIS TIME. BIBLIOGRAPHY / REFERENCES: 1. TECHNICAL INC., PREPARED FOR NIOSH, "HAZOP OF ANHYDROUS AMMONIA USE IN AGRICULTURE", 1991. 2. CLEMENTS ASSOCIATES, INC., FAIRFAX, VA; "HEALTH EFFECTS FOR AMMONIA, PREPARED FOR THE FERTILIZER INSTITUTE". 3. U. S. ENV IRONMENTAL PROTECTION AGENCY "CHEMICAL EMERGENCY PREPAREDNESS AND PREVENTION ADVISORY - AMMONIA", SEPTEMBER 1991 OSWER 91-008.2, SERIES 8; NO.2. 4. ECOLOGY AND ENVIRONMENT, INC., "GENERIC HAZARD ASSESSMENT AND OFF-SITE CONSEQUENCES ANALYSIS KERN AND KINGS COUNTIES", PREPARED FOR CALIFORNIA FERTILIZER ASSOCIATION", OCTOBER 1990. 5. AMERICAN NATIONAL STANDARD INSTITUTE, INC., "AMERICAN NATIONAL STANDARD SAFETY REQUIREMENTS FOR THE STORAGE AND HANDLING OF ANHYDROUS AMMONIA" (K-61.1); MARCH 1989. |