Watonwan Farm Service Co - Executive Summary |
|
Watonwan FArm Service Co PO Box 155 Delavan, Minnesota 56023 For further information contact: Greg Scheid - Safety Director 507-854-3204 Risk Management Plan - Executive Summary 1. The Facility Policy The owners, management and employees of Watonwan Farm Service Co, Easton, Mn. are committed to the prevention of any accidental releases of anhydrous ammonia. If an accidental release should occur, the facility is prepared to work with the local fire department, or other authorities, to mitigate any release and minimize the impact of the release to people and the environment. NOTE: This RMP was revised by Watonwan Farm Service Co on 11-3-99, as we purchased this company on 10-1-99 and the only changes are the owners and contact person. 2. Facility Information The primary activity at the facility is the storage and blending of fertilizers for sale to farmers. Anhydrous ammonia is received, stored and distributed for direct application. Anhydrous ammonia is used for crop prod uction nutrients.. The maximum quantity of ammonia stored would be 310,000 pounds in our 30,000 storage tank and nurse tanks. The maximum quantity handled would be the unloading of a tank truck holding 40,000 pounds. 3. The worst case scenario and the alternative release scenario. a. The worst case scenario for anhydrous ammonia would be the release of the total contents of a storage tank released as a gas over ten minutes. The maximum quantity release would be 130,000 pounds which represents the volume of the storage tank at 85 percent capacity as limited by design standards. The distance to the endpoint (point of dispersion to 200 ppm) is 1.12 miles. b. The alternative release scenario for anhydrous ammonia based on the hazard review is a 2 minute release from a break in a 3 inch pipe. The distance to the endpoint (point of dispersion to 200 ppm) is .78 miles. 4. The accidental release prevention program. The facility has implemented the provisions of "Safety Requireme nts for the Storage and Handling of Anhydrous Ammonia, K-61.1", published by the American National Standards Institute, Inc., and the Standards of the U. S. Occupational Safety and Health Administration (OSHA), 29 CFR 1910.111, "Storage and Handling of anhydrous ammonia". In addition, Minnesota Dept. of Ag Rules. 5. The Five-year Accident History. a. There have been no accidental releases of anhydrous ammonia in the past five years that: have caused any death, injuries, or significant property damage at the facility; nor to our knowledge, have resulted in offsite deaths, injuries, evacuations, sheltering in place, property damage or environmental damage. 6. The emergency Response Program. The facility has: a. A written emergency action plan, in accordance with OSHA standard, 29 CFR 1910.38; b. Provided state and local authorities the emergency planning and community right-to-know information as required under SARA Title III (EPCRA); c. Coordinated with local emergency respo nders. 7. Planned Changes to Improve Safety. Safety improvement is an on-going process at the facility. Periodic evaluations are performed to assess the maintenance of safe conditions. There are no additional specific anhydrous ammonia safety recommendations for implementation at this time. |