Cargill Inc. - Executive Summary |
|
Cargill Inc. 601 Minnesota Ave. P.O. Box 81 Danvers, Mn. 56231 For further information contact Gary Pearson, Operations Manager (320)367-2175 Risk Management Plan - Executive Summary 1. The Facility Policy The owners, management and employees of Cargill Inc. are commited to the prevention of any accidental release of anhydrous ammonia. If an accidential release should occur, the facility is prepared to work with the local fire company, or other authorities, to mitigate any release and minimize the impact of the release to people and the environment. 2. Facility Information The primary activity at the facility is the storage of fertilizer for sale to farmers. Anhydrous ammonia is received, stored and distributed for direct application. Anhydrous ammonia is used for crop production nutrients. The maximum quantity of ammonia stored would be 162,000 pounds in our 12,000 gal. storage tank and nurse tanks. The maximum quantity handled would be the unloading of a truck h olding 40,000 pounds. 3. The worst case release scenario and the alternative release scenario a. The worst case release scenario for anhydrous ammonia would be the release of the contents of the storage tank released as a gas over ten minutes. The maximum quantity released would be 53,000 pounds which represents the volume of the storage tank at 85 percent capacity as limited by design standards. The distance to the endpoint (point dispersion to 200 ppm) is 0.84 miles. b. The alterative release scenario for anhydrous ammonia based on the hazard review is a 2 minute release from a break in a 3 inch pipe. The distance to the endpoint (point of dispersion to 200 ppm) is 0.78 miles. 4. The Accidental Release Prevention Program. The facility has implemented the provisions of "Safety Requirements of the Storage and Handling of Anhydrous Ammonia, K-61.1", published by the American National Standards Institute, Inc. and the Standards of the U.S Occupational Safety and Health Administration (OSHA), 29 CFR 1910.111, Storage and handling of Anhydrous Ammonia". In addition, Minnesota Dept. of Ag. Rules. 5. The Five-Year Accident History a. There have been no accidental releases of anhydrous ammonia in the past five years that: Have caused any death, injuries, or significant property damage at the facility; nor to our knowledge, have resulted in offsite deaths, injuries, evacuation, sheltering in place, property damage or environmental damage. 6. The Emergency Response Program The facility has: a. A written emergency action plan, in accordance with OSHA standard, 29 CFR 1910.38 b. Provided state and local authorities the emergency planning and community right-to-know information as required under SARA Title III (EPCRA) c. Coordinated with local emergency responders 7. Planned Changes to Improve Safety Safety improvements is an on-going process at the facility. Periodic evaluations are performed to assess the mainte nance of safe conditions. There are no additional specific anhydrous ammonia safety recommendations for implementation at this time. |