Fitterer Oil Company New England ND - Executive Summary |
|
For further information contact: Greg Fitterer, Owner RISK MANAGEMENT PLAN - EXECUTIVE SUMMARY I. THE FACILTY POLICY6/19/99 A. THE OWNER, MANAGEMENT, AND EMPLOYEES OF FITTERER OIL, NEW ENGLAND ND, ARE COMMITTED TO THE PREVENTION OF ANY ACCIDENTAL RELEASE OF ANHYDROUS AMMONIA. IF AN ACCIDENTAL RELEASE SHOULD OCCUR, THE FACILITY IS PREPARED TO WORK WITH THE LOCAL FIRE DEPARTMENT, LEPC, OR OTHER AUTHORITIES, TO MITIGATE ANY RELEASE AND TO MINIMIZE THE IMPACT OF THE RELEASE ON PEOPLE AND THE ENVIRONMENT. II. FACILITY INFORMATION: A. THE PRIMARY ACTIVITY AT THE FACILITY IS THE STORAGE AND HANDLING OF ANHYDROUS AMMONIA FOR SALE TO FARMERS. B. ANHYDROUS AMMONIA IS RECEIVED, STORED, AND DISTRIBUTED FOR APPLICATION ON CROPS AS A FERTILIZER NUTRIENT. C. THE MAXIMUM QUANTITY STORED WOULD BE 157,896 POUNDS IN TWO 18,000 GALLON STORAGE TANKS. (Note: maximum quantity allowed to be stored is 85% of storage tank size) III. THE WORST-CASE RELEASE SCENARIO AND THE ALTERNATIVE RELEASE SCENARIO: A. THE WORST-CASE RELEASE SCENARIO WOULD BE THE RELEASE OF THE TOTAL CONTENTS OF A STORAGE TANK OVER TEN MINUTES. THE MAXIMUM QUANTITY RELEASED WOULD BE 157,896 POUNDS, WHICH REPRESENTS THE VOLUME OF THE STORAGE TANK AT 85 PERCENT CAPACITY AS LIMITED BY DESIGN STANDARDS. THE DISTANCE TO THE ENDPOINT (point of dispersion to 200 ppm) IS 2.61 MILES. B. THE ALTERNATIVE RELEASE SCENARIO IS BASED ON A RELEASE FROM A BREAK IN A TRANSFER HOSE. THE DISTANCE TO THE ENDPOINT (point of dispersion to 200 ppm) IS .83 MILES. IV. THE ACCIDENTAL RELEASE PREVENTION PROGRAM: A. THE FACILTY HAS IMPLEMENTED THE PROVISION OF THE SAFETY REQUIREMENTS FOR THE STORAGE AND HANDLING OF ANHYDROUS AMMONIA, K-61.1, PIUBLISHED BY THE AMERICAN NATIONAL STANDARDS INSTITUTE INC. B. THE FACILITY HAS IMPLEMENTED THE STANDARDS OF THE US OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA) 29 CFR 1910.111, STORAGE AND HANDLING OF ANHYDROUS AMMONIA. V. THE FIVE YEAR ACCIDENT HISTORY: A. THERE HAS BEEN NO ACCIDENTAL REL EASES OF ANHYDROUS AMONIA IN THE PAST FIVE YEARS THAT HAVE CAUSED ANY DEATH, INJURIES, OR SIGNIFICANT PROPERTY DAMAGE AT THE FACIL;ITY, NOR HAVE RESULTED IN OFF-SITE DEATHS, INJURIES, EVACUATIONS, SHELTERING IN PLACE, PROPERTY DAMAGE, OR ENVIRONMENTAL DAMAGE. VI. THE EMERGENCY RESPONSE PROGRAM: A. THE FACILITY HAS A WRITTEN EMERGENCY ACTION PLAN, IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.38. B. THE FACILTY HAS PROVIDED TO THE STATE AND LOCAL AUTHORITIES, THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW INFORMATION AS REQUIRED UNDER SARA TITLE III (EPCRA). C. THE FACILTY HAS A WRITTEN EMERGENCY RESPONSE PROGRAM, IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.120, INCLUDING PRE-EMERGENCY PLANNING AND EMPLOYEE TRAINING. VII. PLANNED CHANGES TO IMPROVE SAFETY: A. SAFETY IMPROVEMENT IS AN ON-GOING PROCESS AT THE FACILITY. PERIODIC EVALUATIONS ARE PERFORMED TO ASSESS THE MAINTENANCE OF SAFE CONDITIONS AND EVALUATE EMPLOYEE TRAINING. THERE ARE NO SPECIFIC ANHYDROUS AMMONIA SAFETY REC OMMENDATIONS AT THIS TIME. |