NEW HORIZON FS, INC. - Executive Summary

| Accident History | Chemicals | Emergency Response | Registration | Source | Executive Summary |

The management and employees of New Horizon FS, Inc. are committed to the prevention of any accidental releases of anhydrous ammonia.  If an accidental release should occur, the facility is prepared to work with the local fire department, or other authorities,  to mitigate any release and minimize the impact of the release to people and enviroment. 
The primary activity at the facility is the storage and blending of fertilizer for sale to farmers.  Anhydrous ammonia is received, stored, and distributed for direct application as a crop production nutrient.  Access to the site is restricted to authorized facility employees, authorized management personnel and authorized contractors. 
The maximum quantity of anhydrous ammonia that can be stored would be 56,000 pounds. 
The worst-case release scenario would be the release of the total contents of a storage tand released as a gas over 10 minutes.  the maximum quantity released would be 56,000 pounds, which represents the volume of the largest  
storage tank as limited by design standards. 
The distance to the endpoint of .14 mg/l for the worst-case scenario is .33 mile. 
The altermative relesae scenario based on the most likely potential incident is a release from a break in a transfer hose. 
The distance to the endpoint of .14 mg/l for the altermative scenario is .06 miles.  This release has the possiblility of extending beyond the facility boundary. 
This facility complies with EPA'S Accodemta; Release Prevention Rule and with all applicable state codes and regulations.  This facility has implemented the provisions of "Safety Requirements fpr tje Storage and Handling  of Anhydrous Ammonia, k-61.1", published by The American National Standards Institute, Inc.  as adopted by state regulations and the  standards of the U.S. Occupational Safety and Health Administration (OSHA), 29 CFR 1910.111, "Storage and Handling of Anhydrous Ammonia". 
There have been no accidental releases of anhydrous ammonia in the past five years, that to ou 
r knowldge, have resulted in offsite deaths, injuries, evacuations, shelter in place, property damage, or environmental damage. 
The facility has 
             a written emergency action plan, in accordance with OSHA standard,  29 CFR 1910.38: 
 
             provided state and local authorities the emergency planning and community right-to-know information as required under SARA Title III (EPCRA). 
 
             a written emergency response plan, in accordance with OSHA standard, 29 CFR 1910.120, including pre-emergency plannin and employee training. 
 
Safety improvement is an on-going process at the facility.  Periodic evaluations are performed to assess the maintenance of safe conditions.  There are no specific safety recommendations for implementation at this time.
Click to return to beginning