CENTRAL CO-OP - Executive Summary |
|
CENTRAL CO-OP 75530 STATE HWY. 56 HAYFIELD, MN 55940 FOR FURTHER INFORMATION CONTACT DON NAATZ, PLANT MANAGER, PH. (507)477-3177 RISK MANAGEMENT PLAN -EXECUTIVE SUMMARY 1. THE FACILITY POLICY THE OWNERS, MANAGEMENT, AND EMPLOYEES OF CENTRAL CO-OP ARE COMMITTED TO THE PREVENTION OF ANY ACCIDENTIAL RELEASES OF ANHYDROUS AMMONIA. IF AN ACCIDENTAL RELEASE SHOULD OCCUR, THE FACILITY IS PREPARED TO WORK WITH THE LOCAL FIRE COMPANY, OR OTHER AUTHORITIES, TO MITIGATE ANY RELEASE AND MINIMIZE THE IMPACT OF THE RELEASE TO PEOPLE AND THE ENVIRONMENT. 2. FACILITY INFORMATION THE PRIMARY ACTIVITY AT THE FACILITY IS THE STORAGE AND BLENDING OF FERTILIZERS FOR SALE TO FARMERS. ANHYDROUS AMMONIA IS RECEIVED, STORED AND DISTRIBUTED FOR DIRECT APPLICATION. ANHYDROUS AMMONIA IS USED FOR CROP PRUDUCTION NUTRIENTS. THE MAXIMUM QUANTITY OF AMMONIA STORED WOULD BE 520,000 POUNDS IN OUR TWO 26,000 GALLON STORAGE TANKS AND SIXTY-TWO NURSE TANKS. THE MAXIMUM QUANTITY HANDL ED WOULD BE THE UNLOADING OF A TRUCK HOLDING 40,000 POUNDS. 3. THE WORST-CASE RELEASE SCENARIO AND THE ALTERANATIVE RELEASE SCENARIO. A. THE WORST-CASE RELEASE SCENARIO FOR ANHYDROUS AMMONIA WOULD BE THE RELEASE OF THE TOTAL CONTENTS OF STORAGE TANK RELEASED AS A GAS OVER TEN MINUTES. THE MAXIMUM QUANTITY RELEASED WOULD BE 120,000 POUNDS, WHICH REPRESENTS THE VOLUME OF THE STORAGE TANK AT 85 PERCENT CAPACITY AS LIMITED BY DESIGN STANDARDS. THE DISTANCE TO THE ENDPOINT (POINT OF DISPERSION TO 200 PPM) IS 1.09 MILES. B. THE ALTERNATIVE RELEASE SCENARIO FOR ANHYDROUS AMMONIA BASED ON THE HAZARD REVIEW IS A 2 MINUTE RELEASE FROM A BREAK IN A 3 INCH PIPE. THE DISTANCE TO THE ENDPOINT (POINT OF DISPERSION TO 200 PPM) IS .78 MILES. 4. THE ACCIDENTAL RELEASE PREVENTION PROGRAM. THE FACILITY HAS IMPLEMENTED THE PROVISIONS OF "SAFETY REQUIREMENTS FOR THE STORAGE AND HANDLING OF ANHYDROUS AMMONIA, K-61.1", PUBLISHED BY THE AMERICAN NATIONAL STANDARDS INST ITUTE, INC. AND THE STANDARDS OF THE U.S. OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA), 29 CFR 1910.111, "STORAGE AND HANDLING OF ANHYDROUS AMMONIA". IN ADDITION, MINNESOTA DEPT. AG RULES. 5. THE FIVE-YEAR ACCIDENT HISTORY. A. THERE HAVE BEEN NO ACCIDENTAL RELEASES OF ANHYDROUS AMMONIA IN THE PAST FIVE YEARS THAT: HAVE CAUSED ANY DEATHS, INJURIES, OR SIGNIFICANT PROPERTY DAMAGE AT THE FACILITY; NOR TO OUR KNOWLEDGE, HAVE RESULTED IN OFFSITE DEATHS , INJURIES, EVACUATIONS, SHELTERING IN PLACE, PROPERTY DAMAGE OR ENVIRONMENTAL DAMAGE. 6. THE EMERGENCY RESPONSE PROGRAM. THE FACILITY HAS: A. A WRITTEN EMERGENCY ACTION PLAN, IN ACCORDANCE WITH OSHA STANDARD, 29 CFR 1910.38; B. PROVIDED STATE AND LOCAL AUTHORITIES THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW INFORMATION AS REQUIRED UNDER SARA TITLE III (EPCRA). C. COORDINATED WITH LOCAL EMERGENCY RESPONDERS. 7. PLANNED CHANGES TO IMPROVE SAFETY. SAFETY IMPROVEMENT IS AN ON-GOING PROCESS AT THE FACILITY. PERIODIC EVALUATIONS ARE PERFORMED TO ASSESS THE MAINTENANCE OF SAFE CONDITIONS. THERE ARE NO ADDITIONAL SPECIFIC ANHYDROUS AMMONIA OR PROPANE SAFETY RECOMMENDATIONS FOR IMPLEMENTATION AT THIS TIME. |